'56 TL issue, where to start
|
||||
---|---|---|---|---|
Home away from home
![]() ![]() ![]() |
I am somewhat perplexed by my 56 Executive's TL operation, or lack of operation. The latest issue is that the rear of the car seems to be stuck in the raised position. It was working fine a few months ago (both in auto and manual operations with the 3-way switch under the dash). The 'up' selection of the manual switch engages the solenoid, but the 'down' selection doesn't work. Upon inspection, all components seem to be correct, meaning that the compensator yoke is pointing in the correct direction.
I may have jumped the gun, but I got in a hurry and connected a 12-volt source directly to the compensator motor's down terminal. The motor turned for a few revs and then stops, leaving the rear end still in the raised position. It almost makes me think that the small retaining washer on the compensator's worm gear has failed (again ![]()
Posted on: 2014/10/18 13:07
|
|||
Bob
IF EVERYTHING IS COMING YOUR WAY ... - - - - - - - - - - - - - - - - - - - - - - - - YOU'RE IN THE WRONG LANE! '56 Executive Touring Sedan |
||||
|
Re: '56 TL issue, where to start
|
||||
---|---|---|---|---|
Home away from home
![]() ![]() ![]() |
Quote:
The motor does turn in both directions when powered directly. The short bar is in front and the long bar is in the rear. I only directly drove the motor for a few revs in each direction ('down' until the motor ran until it would run no longer, and 'up' for about 30 seconds). I don't think that the bars pressed into the assy. although both bars are slightly bent from the previous TL system drama. Before driving the motor directly, I had disconnected the small compensator lever rod and moved the lever by hand, back and forth, with no TL motor engagement. I reconnected the small lever control rod and then tried the direct power of the TL motor.
Posted on: 2014/10/18 20:47
|
|||
Bob
IF EVERYTHING IS COMING YOUR WAY ... - - - - - - - - - - - - - - - - - - - - - - - - YOU'RE IN THE WRONG LANE! '56 Executive Touring Sedan |
||||
|
Re: '56 TL issue, where to start
|
||||
---|---|---|---|---|
Forum Ambassador
![]() ![]() ![]() |
Before driving the motor directly, I had disconnected the small compensator lever rod and moved the lever by hand, back and forth, with no TL motor engagement.
Am assuming you waited the amount of time for the delay when manually moving the lever? If so, I would verify you have 12v to ground on the light green wire in the center of the row of terminals at the switch. If that is not present the switch won't work. It is supplied thru two fuses, the brake light switch, and the under dash on/off switch. The fuses are the ones located near the solenoids. The solenoids need a ground to operate which is supplied by relays inside the control switch. To test the solenoids and that part of the circuit directly you can use a jumper wire to ground either of the outside terminals at the control switch. Just do it for a moment long enough to see if the solenoid energizes and motor moves. Also make sure the compensator is in a safe area because grounding at the outside terminals bypasses the limit switches. If neither solenoid or the motor comes in, the 30 amp fuse is blown. If the motor moves in both directions, then go to the next terminal in on either side of center and do the same thing. Those terminals are the output of control switch and goes thru the limit switches. If both solenoids work then something is wrong with voltage in or the control switch. If one of the solenoids does not energize something has activated a limit switch or the switch has failed.
Posted on: 2014/10/18 21:22
|
|||
Howard
|
||||
|
Re: '56 TL issue, where to start
|
||||
---|---|---|---|---|
Home away from home
![]() ![]() ![]() |
I thank you for the great advise and will get to properly examining the TL system accordingly. It's typical of myself to think that "I know the problem..." and jump right in and look for the quick fix. I think that that is where I am weakest and find that I just exasperate the original problem.
I think that you know how helpful this site is and how many Packard owners have benefitted from it's content and all of the knowledge represented here ![]()
Posted on: 2014/10/19 9:46
|
|||
Bob
IF EVERYTHING IS COMING YOUR WAY ... - - - - - - - - - - - - - - - - - - - - - - - - YOU'RE IN THE WRONG LANE! '56 Executive Touring Sedan |
||||
|