Re: Brake Linings
|
||||
---|---|---|---|---|
Forum Ambassador
![]() ![]() ![]() |
Why do you say they need to be riveted? When I relined the shoes for my '34 Eight maybe 40 years ago, I went with molded and bonded lining and I consider the brakes on that car to be exceptional. I know some folks suggest that the thin layer of adhesive inhibits heat transfer to the shoes and that brass rivets enhance transfer; seems logical but I wonder if the difference is enough to make a meaningful difference in fade resistance.
There are those that make a case for woven over molded linings in part to minimize wear on irreplaceable drums. Again, no opinion. Its unlikely my '34 will need new brakes in my lifetime but if it did I'd search out old asbestos molded lining material which is still to be found and rivet it as bonding isn't (to my knowledge) a do-it-yourself operation.
Posted on: 2018/10/6 17:23
|
|||
|
Re: Brake Linings
|
||||
---|---|---|---|---|
Home away from home
![]() ![]() ![]() |
Marston
San Diego area.. Also. 55.56...easy do it yourself..with Arbor press. And clincher... But you should have a brake and clutch outfit in la. My dads 56 would get hot.. Down grades.. Less brake..and use low..
Posted on: 2018/10/6 18:01
|
|||
Riki
|
||||
|
Re: Brake Linings
|
||||
---|---|---|---|---|
Home away from home
![]() ![]() ![]() |
I have 1920's Packards and would never drive them down a steep hill in top gear if I need to use the brakes frequently to hold speed other wise the brakes will overheat. Under those conditions I always change down a gear so that frequent use of the brakes is not required
Posted on: 2018/10/7 3:06
|
|||
|
Re: Brake Linings
|
||||
---|---|---|---|---|
Forum Ambassador
![]() ![]() ![]() |
Marty,
Seeing this thread is in the V8 forum I'm presuming it refers to your lovely '55 Caribbean? Don't know anything about twin ultra's but is it possible to down shift and let engine braking assist as David suggested? Edit - O_D as a Caribbean owner you'd be well versed to answer my question.
Posted on: 2018/10/7 4:37
|
|||
Mal
/o[]o\ ==== ![]() Bowral, Southern Highlands of NSW, Australia "Out of chaos comes order" - Nietzsche. 1938 Eight Touring Sedan - SOLD 1941 One-Twenty Club Coupe - SOLD 1948 Super Eight Limo, chassis RHD - SOLD 1950 Eight Touring Sedan - SOLD What's this? ![]() Put your Packard in the Packard Vehicle Registry! Here's how! Any questions - PM or email me at ozstatman@gmail.com |
||||
|
Re: Brake Linings
|
||||
---|---|---|---|---|
Forum Ambassador
![]() ![]() ![]() |
Yes Mal, Twin Ultramatic has a low range just as conventional Ultramatic does and it is effective in providing additional engine braking when descending long or steep hills.
Posted on: 2018/10/7 7:32
|
|||
|
Re: Brake Linings
|
||||
---|---|---|---|---|
Just popping in
![]() ![]() ![]() |
Check out www.porterfield-brakes.com in Costa Mesa, Ca. They are well known in racing circles. They will reline your shoes with a high performance street lining. As of a couple of months ago their prices were 89.00-109.00 per axle depending on drum size.
As for drum wear, they said there will be virtually no increase, due to the fact that the linings get their performance not from being a lot more aggressive (they are slightly), but from keeping their friction capabilities when hot. I have 2 older station wagons that I plan on upgrading after going on tours in hill country. I can still hear the screaming and smell the linings... ![]()
Posted on: 2018/10/7 10:03
|
|||
|
Re: Brake Linings
|
||||
---|---|---|---|---|
Home away from home
![]() ![]() ![]() |
I didn't notice that the question related to V8's, My comment was about the early cars based on the avatar.
Posted on: 2018/10/7 17:12
|
|||
|
Re: Brake Linings
|
||||
---|---|---|---|---|
Home away from home
![]() ![]() ![]() |
Thanks for all the inputs. I'll look at getting the shoes relined and give porterfield-brakes a call tomorrow. I'll keep everyone posted.
Posted on: 2018/10/7 19:06
|
|||
|
Re: Brake Linings
|
||||
---|---|---|---|---|
Home away from home
![]() ![]() ![]() |
I've used low and they still over heat on short grades where I feel it should be a problem. The last time was on a series of short down hill grade. I was barley able to stop the car before starting down the last grade. I got down to 3 mph and put the car in reverse to stop in time to the them cool down.
Mal the lovely '55 Caribbean you refer to is not mine. It is the wife's car. She informed me a year and a half ago that when she paid the house off she was going to buy a '55 or '56. House was paid for June 2017 and the car was hers less than 2 months later. We bought it at an auction in Limerock CT. Because there was a torrential rain storm the day of the auction we got it at a good price. I'm guessing that we got it for less than 15 to 20K less than what it is worth. She lets me drive it and of course she lets me maintain and work on (LO). After discussing with Porterfield Brakes, I'm going to go with them. I'll wait until after Christmas during our rainy season before doing the job. They are ~75 miles from home and have a 10 day turnaround. I plan on replacing the brake fluid and will use either DOT 4 or 5.1.
Posted on: 2018/10/9 13:46
|
|||
|